SAFETY DATA SHEET
SDS 0013

=============================================================================
            Section 1 -- PRODUCT AND COMPANY IDENTIFICATION                      
-----------------------------------------------------------------------------
                                                           HMIS CODES
PRODUCT NAME                                            Health            1
   RectorSeal No. 5 Sub-Zero                            Flammability      1
                                                        Reactivity        0
PRODUCT CODES                                           PPI               B
   27731, 27651, 27541, 27460, 27371, 27111, 27222
CHEMICAL FAMILY
   Organic
USE
   Pipe Thread Sealant
MANUFACTURER'S NAME                          EMERGENCY TELEPHONE NO.
   The RectorSeal Corporation                 Chemtrec 24 Hours
   2601 Spenwick Drive                        (800)424-9300 USA
   Houston, Texas  77055  USA                 (703)527-3887 International
   
DATE OF VALIDATION                           TECHNICAL SERVICE TELEPHONE NO. 
   January 23, 2015                           (800)231-3345 or (713)263-8001
DATE OF PREPARATION                         
   October 10, 2012   
=============================================================================
           Section 2 -- HAZARDS IDENTIFICATION
-----------------------------------------------------------------------------
EMERGENCY OVERVIEW
OSHA Hazards
Target Organ Effect, Teratogen, Reproductive hazard
Target Organs
Liver, Kidney, Testes.
GHS Classification
Eye irritation (Category 2B)
Reproductive toxicity (Category 2)
-----------------------------------------------------------------------------
GHS Label elements, including precautionary statements
Pictogram: Target Organ Toxicity
Signal Word: Warning
Hazard statement(s)
H320 - Causes eye irritation.
H361 - Suspected of damaging fertility or the unborn child.
Precautionary statement(s)
P281 - Use personal protective equipment as required.
P305 + P351 + P338 IF IN EYES: Rinse cautiously with water for several minutes. 
Remove contact lenses, if present and easy to do. Continue rinsing. 
-----------------------------------------------------------------------------
SUMMARY OF ACUTE HAZARDS
   Irritation to eyes, nose and throat; drowsiness, narcosis, tremors and 
other CNS effects at high concentration.
ROUTE OF EXPOSURE, SIGNS AND SYMPTOMS
INHALATION
   Nasal and respiratory irritation, dizziness, narcosis, headache, nausea,
CNS depression and unconsciousness.
EYE CONTACT
   Watering, blurred vision, inflammation and irritation which can result in
corneal injury.
SKIN CONTACT
   Irritation, dermatitis.
INGESTION
   Nausea, vomiting; CNS depression; irritation of gastrointestinal tract,
liver and peritoneal wall; lung congestion.
SUMMARY OF CHRONIC HAZARDS
   Skin irritation and dermatitis.  Possible liver and kidney damage.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
  Individuals with pre-existing or chronic diseases of the eyes, skin, 
respiratory system, cardiovascular system, gastrointestinal system, liver or 
kidneys may have increased susceptibility to excessive exposures.
=============================================================================
           Section 3 -- COMPOSITION/INFORMATION ON INGREDIENTS
-----------------------------------------------------------------------------
INGREDIENT: Diethylene Glycol Methyl Ether  
PERCENTAGE BY WEIGHT: 16 Max
CAS NUMBER: 111-77-3
EC#  : 203-906-6							 
=============================================================================
           Section 4 -- FIRST AID MEASURES
-----------------------------------------------------------------------------
   If INHALED:     If overcome by exposure, remove victim to fresh air 
                   immediately.  Give oxygen or artificial respiration as 
                   needed.  Obtain emergency medical attention.  Prompt action
                   is essential.
   If on SKIN:     Immediately flush with large amounts of water for at least 
                   15 minutes.  Get prompt medical attention.
   If in EYES:     Flush eyes with large amounts of water for 15 minutes.
                   Get medical attention.
   If SWALLOWED:   If swallowed, call a physician immediately.  Only induce 
                   vomiting at the instruction of a physician.  Never give 
                   anything by mouth to an unconscious person.
=============================================================================
           Section 5 -- FIRE FIGHTING MEASURES
-----------------------------------------------------------------------------
EXTINGUSING MEDIA
   Foam, dry chemical, carbon dioxide or water fog.
SPECIAL FIRE FIGHTING PROCEDURES:  Wear self-contained breathing apparatus 
   (SCBA) and other protective clothing.  Hazardous decomposition products 
   possible (see Section 10).
UNUSUAL FIRE AND EXPLOSION HAZARDS:  None known.
=============================================================================
           Section 6 -- ACCIDENTAL RELEASE MEASURES
-----------------------------------------------------------------------------
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:  Remove all 
   sources of ignition.  Use absorbent materials to prevent footing hazard 
   and to contain.  Ventilate area with natural or explosion-proof, forced 
   air ventilation.  Avoid flushing into sewers, drains, waterways, and soil. 
   Wear protective clothing and respiratory protection during cleanup.  
=============================================================================
           Section 7 -- HANDLING AND STORAGE
-----------------------------------------------------------------------------
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:  Keep container closed and
   upright when not in use.  Do not store near heat, sparks, or open flames. 
OTHER PRECAUTIONS:  Avoid prolonged or repeated contact with skin or 
   clothing.  Empty containers may contain residues; treat as if full and
   observe all products precautions.  Do not reuse empty containers.  
   KEEP OUT OF REACH OF CHILDREN.
=============================================================================
           Section 8 -- EXPOSURE CONTROLS/PERSONAL PROTECTION
-----------------------------------------------------------------------------
INGREDIENT            UNITS
Diethylene Glycol Methyl Ether 
     ACGIH TLV     N/D                   
     OSHA  PEL     N/D
-----------------------------------------------------------------------------
RESPIRATORY PROTECTION (SPECIFY TYPE):  In confined poorly ventilated areas,
   use NIOSH/MSHA approved air purifying or supplied air purifying or 
   supplied air respirators.
VENTILATION - LOCAL EXHAUST:  Acceptable 
SPECIAL:  Explosion-proof equipment.
MECHANICAL (GENERAL):  Preferable
OTHER:  N/A
PROTECTIVE GLOVES:  Wear rubber gloves.
EYE PROTECTION:  Chemical splash goggles (ANSI Z-87.1 or equivalent)
OTHER PROTECTIVE CLOTHING OR EQUIPMENT:  Coveralls recommended.
WORK/HYGIENIC PRACTICES:  Where use can result in skin contact, wash exposed
   areas thoroughly before eating, drinking, smoking, or leaving work area. 
   Launder contaminated clothing before reuse.
=============================================================================
           Section 9 -- PHYSICAL AND CHEMICAL PROPERTIES
-----------------------------------------------------------------------------
BOILING POINT:                         374 F (190 C) @ 760mm Hg 
SPECIFIC GRAVITY (H20 = 1):            1.40
VAPOR PRESSURE (mm Hg):                0.25 @ 77 F (20 C)
MELTING POINT:                         N/A
VAPOR DENSITY (AIR = 1):               >1
EVAPORATION RATE (ETHYL ACETATE = 1):  <1
APPEARANCE/ODOR:                       Gray Paste/Mild Odor
SOLUBILITY IN WATER:                   16%
Flash POINT                            208 F (98 C) SETA CC 
LOWER EXPLOSION LIMIT                  N/D
UPPER EXPLOSION LIMIT                  N/D
VOLATILE ORGANIC COMPOUNDS(VOC)Content
(Theoretical Percentage By Weight):    16% or (160 g/L)
=============================================================================
           Section 10 -- STABILITY AND REACTIVITY 
-----------------------------------------------------------------------------
STABILITY:  Stable
CONDITIONS TO AVOID:  Heat, sparks, open flames, and strong oxidizing.  
   Temperatures above 500 F (260 C).
INCOMPATIBILITY (MATERIALS TO AVOID):  Gaseous oxygen, strong oxidizing 
   materials, molten alkali metals.
HAZARDOUS DECOMPOSITION PRODUCTS:  CO, CO2 and fragmented hydrocarbons.
HAZARDOUS POLYMERIZATION:  Will not occur.
=============================================================================
           Section 11 -- TOXICOLOGY INFORMATION
-----------------------------------------------------------------------------
CHRONIC HEALTH HAZARDS
   No ingredient in this product is an IARC, NTP or OSHA listed carcinogen.
-----------------------------------------------------------------------------
TOXICOLOGY DATA 
Ingredient Name
-----------------------------------------------------------------------------
   Diethylene Glycol Methyl Ether 
                  Oral-Rat LD50:5500 mg/kg 
                  Inhalation-Rat LC50:N/D
=============================================================================
           Section 12 -- Ecological Information
-----------------------------------------------------------------------------
ECOLOGICAL DATA 
Ingredient Name
-----------------------------------------------------------------------------
   Diethylene Glycol Methyl Ether 
                  Food Chain Concentration Potential      N/A
                  WATERFOWL TOXICITY                      N/A
                  BOD                                     34%
                  AQUATIC TOXICITY                        N/A
=============================================================================
           Section 13 -- DISPOSAL CONSIDERATIONS
-----------------------------------------------------------------------------
Waste Classification:  Non-regulated solid waste
Disposal Method:       Approved landfill
Waste from this product is not considered hazardous as defined under the 
  Resource Conservation and Recovery Act (RCRA) 40 CFR 261.  Dispose of in
  accordance with Federal, State, and Local regulation regarding pollution.
=============================================================================
           Section 14 -- TRANSPORTATION INFORMATION
-----------------------------------------------------------------------------
DOT:              Non-Regulated 
OCEAN (IMDG):     Non-Regulated
AIR (IATA):       Non-Regulated
WHMIS (CANADA):   Non-Regulated
=============================================================================
           Section 15 -- REGULATORY INFORMATION
-----------------------------------------------------------------------------
REGULATORY DATA
Ingredient Name
-----------------------------------------------------------------------------
  Diethylene Glycol Methyl Ether 
                  SARA 313          Yes
                  TSCA Inventory    Yes
                  CERCLA RQ         N/A
                  RCRA Code         N/A
=============================================================================
           Section 16 -- OTHER INFORMATION
-----------------------------------------------------------------------------
   This document is prepared pursuant to the OSHA Hazard Communication 
Standard (29 CFR 1910.1200).  The information herein is given in good faith,
but no warranty, expressed or implied is made.  Consult RectorSeal for further
information:  (713) 263-8001