MATERIAL SAFETY DATA SHEET
MSDS 0165
=============================================================================
Section 1 -- PRODUCT AND COMPANY IDENTIFICATION
-----------------------------------------------------------------------------
HMIS CODES
PRODUCT NAME Health 1
Acid - Away Flammability 2
Reactivity 0
PRODUCT CODES PPI B
45003, 45004, 45010
CHEMICAL FAMILY:
Organic
USE
Compressor Burnout Acid Neutralizer
MANUFACTURER'S NAME EMERGENCY TELEPHONE NO.
The RectorSeal Corporation Chemtrec 24 Hours
2601 Spenwick Drive (800) 424-9300
Houston, Texas 77055 USA
VALIDATION DATE TECHNICAL SERVICE TELEPHONE NO.
February 19, 2007 (800) 231-3345
REVISION DATE
February 19, 2007
=============================================================================
Section 2 -- COMPOSITION/INFORMATION ON INGREDIENTS
-----------------------------------------------------------------------------
% by WT CAS No. INGREDIENT UNITS
-- 64742-44-5 Petroleum Oil
ACGIH TLV 5 mg/m3
OSHA PEL 5 mg/m3
=============================================================================
Section 3 -- HAZARDS IDENTIFICATION
-----------------------------------------------------------------------------
SUMMARY OF ACUTE HAZARDS
Repeated inhalation may cause dizziness and nausea. Ingestion may cause
cramps and diarrhea.
ROUTE OF EXPOSURE, SIGNS AND SYMPTOMS
INHALATION
Upper respiratory tract irritation and dizziness.
EYE CONTACT
Irritation, watering may occur.
SKIN CONTACT
Frequent or prolonged contact may irritate and cause dermatitis.
INGESTION
May cause nausea, vomiting and gastro-intestinal irritation.
SUMMARY OF CHRONIC HAZARDS
Prolonged skin contact may result in irritation and dermatitis.
Prolonged eye contact may result in irritation or chemical burns.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
Individuals with pre-existing or chronic diseases of the eyes, skin
or persons with chemical sensitivity may have increased susceptibility to
excessive exposures.
=============================================================================
Section 4 -- FIRST AID MEASURES
-----------------------------------------------------------------------------
If INHALED: If overcome by exposure, remove victim to fresh air
immediately. Give oxygen or artificial respiration as
needed. Obtain emergency medical attention. Prompt action
is essential.
If on SKIN: Wash with soap and water. Remove contaminated clothing.
If irritation occurs, seek medical attention.
If in EYES: Flush with large amounts of water for at least 15 minutes.
Get medical attention if irritation persists.
If SWALLOWED: If swallowed, call a physician immediately. Only induce
vomiting at the instruction of a physician. Never give
anything by mouth to an unconscious person.
=============================================================================
Section 5 -- FIRE FIGHTING MEASURES
-----------------------------------------------------------------------------
FLASH POINT LEL UEL
>148 F (64 C) SETA CC N/D N/D
EXTINGUSING MEDIA
Foam, dry chemical, carbon dioxide or water fog.
SPECIAL FIRE FIGHTING PROCEDURES: Wear self-contained breathing apparatus
(SCBA) and other protective clothing. Hazardous decomposition products
possible (see Section 10).
UNUSUAL FIRE AND EXPLOSION HAZARDS: Combustible - moderate flash point.
Heat may build up pressure and rupture closed containers.
=============================================================================
Section 6 -- ACCIDENTAL RELEASE MEASURES
-----------------------------------------------------------------------------
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Remove all sources
of ignition. Use absorbent materials to prevent footing hazard and to
contain. Ventilate area with natural or explosion-proof, forced air
ventilation. Avoid flushing into sewers, drains, waterways, and soil.
Wear protective clothing and respiratory protection during cleanup.
=============================================================================
Section 7 -- HANDLING AND STORAGE
-----------------------------------------------------------------------------
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Keep container closed and
upright when not in use. Do not store near heat, sparks, or open flames.
OTHER PRECAUTIONS: Avoid prolonged or repeated contact with skin or
clothing. Empty containers may contain residues; treat as if full and
observe all products precautions. Do not reuse empty containers.
KEEP OUT OF REACH OF CHILDREN.
=============================================================================
Section 8 -- EXPOSURE CONTROLS/PERSONAL PROTECTION
-----------------------------------------------------------------------------
RESPIRATORY PROTECTION (SPECIFY TYPE): In confined poorly ventilated areas,
use NIOSH/MSHA approved air purifying or supplied air purifying or supplied
air respirators.
VENTILATION - LOCAL EXHAUST: Acceptable
SPECIAL: Explosion-proof equipment
MECHANICAL (GENERAL): Preferable
OTHER: N/A
PROTECTIVE GLOVES: Rubber or neoprene
EYE PROTECTION: Chemical splash goggles (ANSI Z-87.1 or equivalent)
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Coveralls recommended.
WORK/HYGIENIC PRACTICES: Where use can result in skin contact, wash exposed
areas thoroughly before eating, drinking, smoking, or leaving work area.
Launder contaminated clothing before reuse.
=============================================================================
Section 9 -- PHYSICAL AND CHEMICAL PROPERTIES
-----------------------------------------------------------------------------
BOILING POINT: 320 F (160 C) @ 760mm Hg
SPECIFIC GRAVITY (H20 = 1): 0.9
VAPOR PRESSURE (mm Hg): <5 @ 68 F (20 C)
MELTING POINT: N/A
VAPOR DENSITY (AIR = 1): >5
EVAPORATION RATE (ETHYL ACETATE = 1): <1
APPEARANCE/ODOR: Pale Yellow Oil/Petroleum Odor
SOLUBILITY IN WATER: Insoluble
VOLATILE ORGANIC COMPOUNDS(VOC)Content
(Theoretical Percentage By Weight): 0% or (0 g/L)
=============================================================================
Section 10 -- STABILITY AND REACTIVITY
-----------------------------------------------------------------------------
STABILITY: Stable
CONDITIONS TO AVOID: Heat, sparks, open flames, and strong oxidizing
conditions.
INCOMPATIBILITY (MATERIALS TO AVOID): Gaseous oxygen and strong oxidizing
materials.
HAZARDOUS DECOMPOSITION PRODUCTS: CO, CO2 and fragmented hydrocarbons.
HAZARDOUS POLYMERIZATION: Will not occur.
=============================================================================
Section 11 -- TOXICOLOGY INFORMATION
-----------------------------------------------------------------------------
CHRONIC HEALTH HAZARDS
No ingredient in this product is an IARC, NTP or OSHA listed carcinogen.
-----------------------------------------------------------------------------
TOXICOLOGY DATA
Ingredient Name
-----------------------------------------------------------------------------
Petroleum Oil
Oral-Rat LD50: N/D
Inhalation-Rat LC50: N/D
=============================================================================
Section 12 -- Ecological Information
-----------------------------------------------------------------------------
ECOLOGICAL DATA
Ingredient Name
-----------------------------------------------------------------------------
Petroleum Oil
Food Chain Concentration Potential N/D
WATERFOWL TOXICITY N/D
BOD N/D
AQUATIC TOXICITY N/D
=============================================================================
Section 13 -- DISPOSAL CONSIDERATIONS
-----------------------------------------------------------------------------
Waste Classification: Non-regulated waste oil
Disposal Method: Used oil recycler
Waste from this product is not considered hazardous as defined under the
Resource Conservation and Recovery Act (RCRA) 40 CFR 261. Dispose of in
accordance with Federal, State, and Local regulation regarding pollution.
=============================================================================
Section 14 -- TRANSPORTATION INFORMATION
-----------------------------------------------------------------------------
DOT: Non-Regulated
OCEAN (IMDG): Non-Regulated
AIR (IATA): Non-Regulated
WHMIS (CANADA): Non-Regulated
=============================================================================
Section 15 -- REGULATORY INFORMATION
-----------------------------------------------------------------------------
REGULATORY DATA
Ingredient Name
-----------------------------------------------------------------------------
Petroleum Oil
SARA 313 No
TSCA Inventory Yes
CERCLA RQ N/A
RCRA Code N/A
=============================================================================
Section 16 -- OTHER INFORMATION
-----------------------------------------------------------------------------
This document is prepared pursuant to the OSHA Hazard Communication
Standard (29 CFR 1910.1200). The information herein is given in good faith,
but no warranty, expressed or implied is made. Consult RectorSeal for further
information: (713) 263-8001